Monessen Hearth VFCS20DPV Oven User Manual


  Open as PDF
of 32
 
58D6002 23
1. Openstovedoor.Removeanyitemsnecessaryforeasyaccesstothepilot(forexample:logs,screens,
etc.).
2. Followappropriatelightinginstructionsfoundpreviously.Lightamatchandholdtheametotheendof
thepilotandignitethepilot.
3. Aftercontrolknobhasbeenreleasedandpilotstayslit,reinstallanyitemsthatwereremovedforpilot
access. Close and latch stove door.
4. Callaqualiedservicetechnicianforrepairorreplacementofthepiezoignitor.
OPERATING INSTRUCTIONS and CLEANING AND SERVICING
CLEANING AND SERVICING
Annual inspection and cleaning by your dealer or qualified service technician is recommended to prevent
malfunction and/or sooting.
PERIODIC CLEANING - See parts diagram for location of items discussed below.
• Donotusecleaninguidtocleanlogsoranypartofheater.
• Brushlogswithsoftbristlebrushorvacuumwithbrushattachment.
• Vacuumlooseparticlesanddustfromthefrontandrearburners,controlandpiezocoversandgrateweldment.
• Inspectandcleanburnerairintakeholes.Removelintorparticleswithvacuum,brush,orpipecleaners.Failuretokeep
airintakeholescleanwillresultinsootingandpoorcombustion.
• Externalcaseshouldbedustedandwipedwithamoistcloth.
ANNUAL CLEANING/INSPECTION - Refer to parts diagram for location of items discussed below.
• Inspectandcleanburnerairintakeholes.Removelintorparticleswithvacuum,brushorpipecleaners.Failuretokeep
airintakeholescleanwillresultinsootingandpoorcombustion.
• Inspect and clean all burner ports.
• InspectODSpilotforoperationandaccumulationoflintatairintakeholes.
• Verifyamepatternandlogplacementforproperoperation.
• Verifysmoothandresponsiveignitionofmainburnerandrearburner.
Turn off heater and allow to cool before
cleaning. Disconnect electrical power
before cleaning or servicing.
WARNING
Removelogs,handlingcarefullybyholdinggentlyateachend.Glovesarerecommendedtopreventskinirritationfrom
ceramicbers.Ifskinbecomesirritated,washgentlywithsoapandwater.Refertomanualforcorrectlogplacement.
MATCH LIGHTING INSTRUCTIONS
 previous next