Filter
Top Products
PAGE 20 — MVC-88VGE/VGEW PLATE COMPACTOR — OPERATION & PARTS MANUAL — REV. #1 (01/11/11)
l
MVC-88VGE/VGEW — MAINTENANCE
Daily Service
■
Check for leakage of fuel or oil.
■
Check engine oil.
■
Check for loose screws including tightness. See Table 6
below (tightening torque ), for retightening.
ENGINE OIL
1. Drain the engine oil when the oil is
warm
as shown in
Figure 14.
2. Remove the dipstick and then unscrew the oil plug and
allow the oil to drain into a suitable container.
3. Replace engine oil with recommended type oil as listed
in Table 3. For engine oil capacity, see Table 2 (engine
specifications). DO NOT overfill.
4. Install drain bolt with sealing washer and tighten se-
curely.
Figure 14. Engine Oil (Draining)
ENGINE AIR CLEANER
1. Remove the air cleaner cover and foam filter element as
shown in Figure 15.
2. Tap the paper filter element (Figure 15) several times on a
hard surface to remove dirt, or blow compressed air [not
exceeding 30 psi (207 kPa, 2.1 kgf/cm
2
) through the filter
element from the air cleaner case side.
NEVER
brush off dirt.
Brushing will force dirt into the fibers. Replace the paper filter
element if it is excessively dirty.
3. Clean foam element in warm, soapy water or nonflammable
solvent. Rinse and dry thoroughly. Dip the element in clean
engine oil and completely squeeze out the excess oil from the
element before installing.
NOITCEPSNIENIHCAM.5ELBAT
metI noitarepOfosruoH skrameR
)kcehcgnitratS(
yreve(sruoh8yrevE
)yad
tsolrodenesooL
swercs
yreve(sruoh8yrevE
)yad
trapynafoegamaD
yreve(sruoh8yrevE
)yad
gnillortnocfonoitcnuF
trapmetsys
yreve(sruoh8yrevE
)yad
kcehcliorotarbiV sruoh001yrevE .91egapeeS
liorotarbiV
tnemecalper
sruoh002yrevE .91egapeeS
kcehc)hctulc(tleb-V ruoh002yrevE .91egapeeS
.6ELBAT
retemaiD)mc/gk.ni(EUQROTGNINETHGIT
lairetaM
mm6 mm8 mm01 mm21 mm41 mm61 mm81 mm02
T4 07 051 003 005 057 001,1 004,1 000,2
T8-6 001 052 005 008 003,1 000,2 007,2 008,3
T11 051 004 008 002,1 000,2 009,2 002,4 006,5
* )mm01(007~056)mm8(053~003)mm6(001
)munimulafositrap-retnuocesacnI(*
)dednahthgirllaeraenihcamsihthtiwesunisdaerhT(
,tlobhcaenodekramsilairetamfoytilauqdnalairetaM
.wercsdna