Filter
Top Products
Introduction
This product manual contains the information
needed for the setup, installation, initial start up,
sanitation and maintenance of this ice machine.
Keep it for future reference.
There are 2 models covered in this manual:
• CME1356R, (5 evaporators)
• CME1656R, (6 evaporators)
Be certain that the information applies to the model
in question. If no model is listed, the information
applies to all models.
This manual is organized in the same way as the
expected use of the machine, it begins with
specifications, goes thru unpacking and setup,
shows where everything is; continues with initial
start up, then describes how it works. After that is
the sanitation section, followed by service diagnosis
and repair.
TABLE OF CONTENTS
Specifications .................PAGE2
Condenser and Ice Machine Layouts .....PAGE3
Pre-Installation .................PAGE4
Location & Assembly .............PAGE5
Bin Control: Installation ............PAGE6
Bin Control ...................PAGE7
Stacking ....................PAGE8
For The Installer: Remote Condenser .....PAGE10
Remote Condenser Location .........PAGE11
Coupling Instructions .............PAGE12
Head Pressure Control Add-On Kit ......PAGE13
Electrical ....................PAGE14
Plumbing ....................PAGE15
After Utility Connections ............PAGE16
Component Location and Function ......PAGE17
AutoIQ Controller ...............PAGE18
Initial Start Up .................PAGE19
Adjustments ..................PAGE20
How To Operate The AutoIQ Controller ....PAGE21
How The Electronic Cuber Works .......PAGE22
Technicians Only: Freeze Cycle Sequence . . PAGE 24
Technicians Only: Harvest Cycle Sequence & Other
Notes .....................PAGE25
Sanitation and Cleaning ........... PAGE 26
Additional Maintenance ........... PAGE 27
Additional Maintenance: Water Distributors . PAGE 28
Additional Maintenance: Inlet Water Valve
Screen .................... PAGE 29
Additional Maintenance: Ice Sensors,
Condenser .................. PAGE 30
Service Diagnosis: Diagnostic Light Analysis PAGE 31
Service Diagnosis .............. PAGE 32
Service Diagnosis: Components ....... PAGE 33
Service Diagnosis .............. PAGE 34
PTCR ..................... PAGE 35
Operational Characteristics: CME1356R . . . PAGE 36
Operational Characteristics: CME1656R . . . PAGE 37
Removal and Replacement ......... PAGE 38
Removal and Replacement ......... PAGE 39
Removal and Replacement: AutoIQ Controller
........................ PAGE 40
Removal and Replacement: Water Level Sensor
........................ PAGE 41
Removal and Replacement ......... PAGE 42
Refrigerant .................. PAGE 43
Before Calling for Service .......... PAGE 45
Parts Lists and Wiring Diagrams are in the section at the center of this manual.
CME1356R and CME1656R
May 2000
Page 1