Filter
Top Products
10
WWW.WEBER.COM
®
Note - All factory-made connections have been thoroughly checked for gas leaks. The
burners have been flame-tested. As a safety precaution however, you should recheck all
fittings for leaks before using your Weber
®
Gas Barbecue. Shipping and handling may
loosen or damage a gas fitting.
ƽ WARNING: Perform these leak checks even if your
barbecue was dealer or store assembled.
You will need: a soap and water solution, and a rag or brush to apply it.
Note - Since some leak test solutions, including soap and water, may be slightly
corrosive, all connections should be rinsed with water after checking for leaks.
Make sure side burner is OFF.
To perform leak checks: open cylinder valve by turning the cylinder valve hand-wheel
counterclockwise.
ƽ WARNING: Do not ignite burners when leak checking.
Check for leaks by wetting the connections with the soap and water solution and
watching for bubbles. If bubbles form or if a bubble grows, there is a leak.
Check:
1) Gas Line-to-”T” Connection
2) Regulator-to-Cylinder connection.
ƽ WARNING: If there is a leak at connection (1), retighten the
fitting with a wrench and recheck for leaks with soap and
water solution.
If a leak persists after re-tightening the fitting, turn OFF
the gas. DO NOT OPERATE THE GRILL. Contact Customer
Service 1-800-446-1071.
Check:
3) “T” Connection-to-Hose connections.
4) The hose-to-Regulator connection.
ƽ WARNING: If there is a leak at connections (2,3, or 4),
turn OFF the gas. DO NOT OPERATE THE GRILL. Contact
Customer Service 1-800-446-1071.
When leak checks are complete, turn gas supply OFF at the source and rinse
connections with water.
(2)
(4)
Side View
Side View
(3)
(1)
GAS INSTRUCTIONS
ƽ ATTENTION: This product has been safety tested
and is only certified for use in a specific country. Refer
to country designation located on outer carton.
These parts may be gas carrying or gas burning components. Please
contact Weber-Stephen Products Co., Customer Service Department
for genuine Weber-Stephen Products Co. replacement part(s)
information.
ƽ WARNING: Do not attempt to make any repair to
gas carrying or gas burning components without
contacting Weber-Stephen Products Co., Customer
Service Department. Your actions, if you fail to follow
this product Warning, may cause a fire or an explosion
resulting in serious personal injury or death and
damage to property.