Quadra-Fire 7068-112 Cooktop User Manual


  Open as PDF
of 32
 
Page10
August 19, 2011
Castile & Santa Fe CE Pellet Stove
R
7068-112
H. Fire Characteristics
Aproperlyadjustedrewiththeheatoutputcontrolswitch
seton“high”hasashortactiveamepatternthatextends
outoftherepotapproximately102mm.Iftherehastall
ameswithblacktailsandseemssomewhatlazy,thefeed
ratewillneedtobereduced.Thisisdonebyslidingthefuel
adjustmentcontrolroddown,whichwillreducethefeed.If
thereisnot102mmtall,slidethefueladjustmentcontrol
roduptoincreasethefeed.Amediumandlowsettingwill
giveashorterame.Theamewillriseandfallsomewhat.
Thisisnormal.
Figure 10.2
Thefeedadjustmentcontrolrodisfactoryset,andshould
beadequateformostfuels.However,iftheflameheightis
toohighortoolow,youwillneedtoadjustthefeedrate.Wait
untiltheappliancehasbeenburningfor15minutesbefore
makingyouradjustmentsanda
llow15minutesforfeed
adjustmenttotakeeffect.
I. Feed Rate Adjustment Instructions
1. Loosenthesetscrew 1/4to1/2turn duringset-up
ofappliance.Thiswillallowmovementofthefeed
adjustmentcontrolrod.Donotre-tightensetscrew.
2.Loosenthewingnut.
3.Adjustthefeedadjustmentcontrolrodupwardtowardsthe
"+"symboltoincreasethefeedrateandameheightor
downtowardsthe"-"symbol,todecreasethefeedrate
andameheight.Figure 10.2.
4.Re-tightenthewingnut.
Feed Adjustment Control Rod
Set Screw
Wing Nut
J. Iginition Cycles
1. Atthebeginningofeachignitioncycle,itisnormaltosee
somesmokeintherebox.Thesmokewillstoponcethe
restarts.
2. Theconvectionblowerwillautomaticallyturnonafteryour
appliancehasbeenburningforapproximately10minutes.
Thisblowertransfersheatfromyourapplianceintothe
room,andwillcontinuetorunafterthethermostathas
stoppedcallingforheatuntiltheappliancehascooled
down.
3.
Occasionallytheappliancemayrunoutoffuelandshut
itselfdown.Whenthishappens,theredcalllightwillbe
on. Figure 10.1.Torestartit,llthehopperandpressthe
resetbutton.See Figure 9.1 on page 9.Whenyoupress
theresetbuttontheredcalllightwillgoout.Releasethe
buttonandthelightwillcomebackon.Youshouldsee
areshortly.Ifnot,followtheinstructionsonpage 9of
“StartingYourFirstFire”.
WARNING
FireRisk
DoNOToperateappliance:
• Withappliancedooropen.
• Firepotooropen.
• Cleaningslideplatesopen.
DoNOTstorefuel:
• Closerthanrequiredclearancestocom-
bustiblestoappliance
• Withinspacerequiredforloadingorash
removal.
6. Oncetheappliancehasignited,letitburnforapproximately
15minutes,thensetthethermostattothedesiredroom
temperature.Adjusttheheatoutputcontrolswitchtothe
desiredsetting.
WARNING! RISK OF FIRE! Keepcombustiblematerials,
gasolineandotherammablevaporsandliquidsclearof
appliance.
• DoNOTstoreammablematerialsintheappliance’s
vicinity.
• DoNOTusegasoline,lanternfuel,kerosene,charcoal
lighteruidorsimilarliquidstostartor“freshenup”are
inthisheater.
Keepallsuchliquidswellawayfromtheheaterwhileitisin
useascombustiblematerialsmayignite.
K. Clear Space
WARNING! RISK OF FIRE! DoNOTplacecombustible
objectsinfrontoftheappliance.Hightemperaturesmay
igniteclothing,furnitureordraperies.Maintainaminimum
clearanceof914mminfrontofappliance.
NOTICE: Clearancesmayonlybereducedbymeansap-
provedbytheregulatoryauthorityhavingjurisdiction.
Mantel:
  Avoid placing candles and other heat-sensitive
objects on mantel or hearth.  Heat may damage these
objects.
Figure 10.1
Red Call Light
 previous next