Quadra-Fire 7068-112 Cooktop User Manual


  Open as PDF
of 32
 
R
August 19, 2011
Page9
Castile & Santa Fe CE Pellet Stove
7068-112
E. Before Your First Fire
1. First,makesure yourappliancehasbeenproperly
installedandthatallsafetyrequirementshavebeenmet.
Payparticularattentiontothereprotection,ventingand
thermostatinstallationinstructions.
2. Doublecheckthattheashdrawerandreboxareempty!
3. Closethefrontdoor.
IMPORTANT DETAIL: The tip of the thermocouple must
be in contact with the inside end of the thermocouple
cover or missed ignitions can occur.
G. Starting Your First Fire
1. Athermostatisrequiredforproperoperation ofthis
appliance.Atthistime,llthehopperwithpellets,set
thethermostattoitslowestsetting.Plugthepowercord
intonearbyoutlet.
2. Theexhaustblower willstayonforapproximately 18
minuteseventhoughthethermostatisnotcallingfor
heat.Thisisnormal.
3. L
ocatetheheatoutput controlswitchmountedon the
backoftheapplianceintheupperrightcorner.Figure
9.1. Turnittothe“high”settingbypushingthetopof
thecontrolswitchinandthenadjustthethermostattoits
highestsetting.Removetherightsidepanelandthered
calllightlocatedtotheleftofthecontrolboxwillbeon.
Figure 10.1.Thisindicatesthethermostatiscallingfor
heat.
4.
Thefuelfeedsystemandtheignitershould
now
beon.
5. Foryourrstreitwillbenecessarytopressthereset
buttononceapproximately2minutesafterstartupand
againin5minutes.Thiswillllthefeedsystemandallow
theappliancetobegindroppingpellets.Theappliance
willcontinuetorunaslongasthethermostatiscalling
forheat.
D. General Operating Information
1. Thermostat Calls For Heat
Theapplianceislike mostmodernfurnaces;whenthe
thermostatcallsforheat,yourappliancewill automatically
lightanddeliverheat.Whentheroomisuptotemperature
andthethermostatissatised,theredcalllightwillgooff
andtheappliancewillshutdown.
2. Heat Output Controls
Thisapplianceisequippedwithaheatoutputcontrolswitch
thathasthreesettingsorburnrates;low,mediumandhigh.
Theappliancewillturnonandoffasthethermostatdemands.
Whenthethermostatcallsforheat,theappliancewillstart
upattheburnrateforwhichitisset.Iftheapplianceisset
atoneofthelowersettings,itwillrunquieterbuttakelonger
toheatupanareathanifitweresetatahigherburnrate.
Regardlessoftheburnrate,whentheareaiswarmenough
tosatisfythethermostat,theappliancewillshutoff.
Figure 9.1
WARNING
FireHazard.
Keepcombustiblematerials,gasoline
andotherammablevaporsandliquids
clearofappliance.
• DoNOTstoreammablematerialsintheappliance’s
vicinity.
• DONOTUSEGASOLINE,LANTERNFUEL,
KEROSENE,CHARCOALLIGHTERFLUIDOR
SIMILARLIQUIDSTOSTARTOR“FRESHENUP”A
FIREINTHISHEATER.
• DONOTBURNGARBAGEORFLAMMABLEFLUIDS
SUCHASGASOLINE,NAPHTHAORENGINEOIL.
• DONOTUSECHEMICALSOFFLUIDSTOSTART
THEFIRE.
• Keepallsuchliquidswellawayfromtheheaterwhileit
isinuse.
• Combustiblematerialsmayignite.
High
Med
Low
Heat Output Switch
Reset Button
Reset
Button
F. Filling the Hopper with Fuel
1. Openthehopperlidandpullthelidtowardsyou.Thelid
cannowserveasashelftosupportthebagoffuel.
2. Donotoverllthehopper.Thelidmustbecompletely
closedtomaintainpropervacuumandforthefeedmotor
tooperate.Anerrormessagewillappearonthewall
controlifthelidisnotproperlyclosed.
3. Removeanysawdustorfuelfromthelidgasketafter
rellinghopper.
4. Donotleaveanypartofthefuelbagontheappliance
afterrellinghopper.
5. Storefuelawayfromtheappliancetomaintainproper
safeairclearancetocombustibles.
 previous next