Filter
Top Products
COMBITOUCH
®
ESG SERIES • GAS INSTALLATION MANUAL • MN-29246 • 13.
20• 20ESG
[A,B] 4-3/8" (110mm)
[D] 4-9/16" (116mm)
[C] 3-9/16"
(89mm)
Water Drain
(Side Back)
[D] 4-5/8" (116mm)
2" (50mm)
55-7/16"
(1407mm)
73-13/16" (1875mm)
5-7/8"
(148mm)
17-1/4"
(438mm)
19-11/16"
(500mm)
26-9/16"
(675mm)
19-15/16"
(506mm)
D
A = UNTREATED WATER
B = TREATED WATER
C = ELECTRICAL
D = GAS
C
B
A
Steam
Vents
(Top)
49-13/16" (1264mm)
47-13/16" (1214mm)
44" (1118mm)
2"
(49mm)
8-15/16" (226mm)
76-5/8" (1946mm)
74-9/16" (1893mm)
65-5/8" (1667mm)
30-5/8"
(778mm)
32-13/16"
(833mm)
2-3/16"
(56mm)
Water Drain
(Bottom)
7-11/16" (195mm)
45-3/16" (1148mm)
42-9/16" (1080mm)
WEIGHT CAPACITY
NET 900 lb est (408 kg) FULL-SIZE PANS: 20" x 12" x 2-1/2" Forty (40)
SHIP 1227 lb (557 kg) GN 1/1: 530 x 325 x 65mm Forty (40)
CRATE DIMENSIONS: (L x W x H)
GN 2/1: 650 x 530 x 65mm Twenty (20)
54" x 49" x 85" FULL-SIZE SHEET PANS:* 18" x 26" x 1" Twenty (20)
(1374 x 1245 x 2159mm)
ON WIRE SHELVES ONLY
480 lb (218 kg) MAXIMUM
VOLUME MAXIMUM: 300 quarts (380 liters)
*ADDITIONAL WIRE SHELVES REQUIRED FOR MAXIMUM CAPACITY
GAS REQUIREMENTS (
TYPE MUST BE SPECIFIED ON ORDER
)
INSTALLATION REQUIREMENTS
CONNECTED ENERGY LOAD:
190,000 Btu / hr (Natural Gas)
•Ovenmustbeinstalledlevel.
•Hoodinstallationisrequired.
•Watersupplyshut-offvalveandback-flowpreventerwhen
required by local code.
•Alternateburnerorificeisrequiredforinstallationsitesat
elevations of 2,000 feet (610m) above sea level.
170,000 Btu / hr (Propane)
HOOK-UP:
3/4"
NPT
MINIMUM CONNECTED PRESSURE:
5.5" W.C. (Natural Gas)
9" W.C. (Propane)
MAXIMUM CONNECTED PRESSURE:
14" W.C.
ELECTRICAL
(DEDICATED CIRCUIT REQUIRED)
CombiSmoker®
MODEL
VOLTAGE PH HZ AMPS kW AWG CORD & PLUG Additional kW
20•20ESGTouch
120 1 60 9.0 1.04 AWG 12 NEMA 5-20P, 20A, 125V Plug
SK NOT AVAILABLE
208 – 240 1 60 5.0 1.04 AWG 12 no cord or plug + .7 kw
208 – 240 3 60 5.0/ph 1.04 AWG 12 no cord or plug + .7 kw
380 – 415 3 50 2.0/ph 1.44 AWG 12 Bare End, 3 Wire + ground +.7 kw
20•20ESG
120 1 60 12.2 1.40 AWG 12 NEMA 5-20P, 20A, 125V Plug
SK NOT AVAILABLE
208 – 240 3 60 4.27/ph 1.54 AWG 12 Bare End, 3 Wire + ground + .7 kw
WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS
TWO (2) COLD WATER INLETS - DRINKING QUALITY
ONE (1) TREATED WATER INLET: 3/4" NPT*
ONE (1) UNTREATED WATER INLET: 3/4" NPT*
LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar
WATER DRAIN:
1-1/2"
connection
WitH
a
2"
MiniMuM
air
Gap
installed
as
close
to
tHe
oven
as
possiBle
.
Materials
Must
WitHstand
teMperatures
up
to
200°f (93°c).
USING A WATER SUPPLY NOT MEETING ALTO-SHAAM’S MINIMUM
WATER QUALITY STANDARDS WILL VOID THIS WARRANTY.
It is the responsibility of the purchaser to ensure that incoming water supply is
compliantwiththespecificationslistedthroughadequatetreatmentmeasures.
Installation of the CombiGuard
TM
Water Filtration System is recommended, but
this system may not address all water quality issues present.
CLEARANCE REQUIREMENTS
Contaminant
Free Chlorine
Hardness
Chloride
pH
Alkalinity
Silica
Total Dissolved Solids (tds)
Inlet Water Requirements (
untreated water
)
Less than 0.1 ppm (mg/L)
Less than 3 gpg (52 ppm)
Less than 30 ppm (mg/L)
7.0 to 8.5
Less than 50 ppm (mg/L)
Less than 12 ppm (mg/L)
Less than 60 ppm
LEFT 6" (152mm)
RECOMMENDED SERVICE ACCESS: 18" (457mm)
20" (508mm)
FROM HEAT PRODUCING EQUIPMENT
RIGHT 4" (102mm) TOP: 20" (508mm)
FOR AIR MOVEMENT
BACK 4" (102mm) BOTTOM: 5-1/8" (130mm)
FOR LEGS
* Can manifold off of
one 3/4" line.
DIMENSIONS: H x W x D
EXTERIOR:
76-5/8" x 49-13/16" x 45-3/16" (1946mm x 1264mm x 1148mm)
EXTERIOR WITH RECESSED DOOR:
76-5/8" x 53-13/16" x 45-3/16" (1946mm x 1366mm x 1148mm)
INTERIOR:
54-15/16" x 25-1/4" x 33-7/8" (1395mm x 640mm x 860mm)