Filter
Top Products
MAINTENANCE - FILTER SYSTEM (continued)
26
NOTE:
Oil should be at least 300ºF (149ºC) DO NOT attempt to filter cold oil.
DO NOT attempt to pump oil when less than 300ºF. Cold oil will not
pass through the filter paper. Filtering cold oil will result in the
premature failure of the filter pump. Damage as a result of pumping
cold oil IS NOT COVERED BY WARRANTY.
NOTE:
DO NOT store oil in the reservoir for any extended period, including
overnight.
IMPORTANT:
The filtration system in your Wells Fryer is designed to filter hot liquid
shortening ONLY. Water, cleaning agents or other liquids will
damage the filter pump and may contaminate the food product
Press POWER SWITCH (item 1) to FILTER. Pump motor will be
energized and heating elements are de-energized.
Remove and examine filter reservoir:
• Verify that filter leaf is clean and properly installed.
• Verify that suction tuibe o-ring is in place and in good condition.
• Make absolutely certain that no water remains in bottom of
reservoir or in suction tube.
Reinstall reservoir, making sure the SUCTION TUBE is firmly seated
in the SUCTION RECEPTACLE.
Press FILTER PUMP SWITCH (item 8) to ON to start filter pump.
Slowly rotate DRAIN VALVE LEVER (item 11) to the vertical position.
Oil will drain from the frypot and into the reservoir. Filter pump will
draw oil through the filter leaf and return it to the frypot.
CAUTION
BURN HAZARD
Protective clothing and gloves
must be worn during the filtering
process
CAUTION
BURN HAZARD
Filter reservoir may be hot.
Wear insulated gloves, or
allow reservoir to cool,
before touching it.
IMPORTANT:
Filtering cooking oil helps to
ensure the quality of the food
product. Careful observation of
the finished food product will
help you determine the optimal
filtering frequency.
(Example: Filter the oil after
each six loads of fresh breaded
chicken)
FILTER POWDER absorbs
acids and many other
contaminants in the cooking oil,
allowing the oil to be used
longer before it must be
replaced. Wells Flavor Saver
Oil Filter Powder is available
from your Wells Equipment
Dealer or Authorized Service
Agent in a case of 45 packages
(p/n 22410).
363 300007 OpManual for WFAE-50F/FS Electric Fryer
WARNING
WARNING: BURN HAZARD
BE ABSOLUTELY CERTAIN THAT NO WATER REMAINS
IN RESERVOIR OR SUCTION TUBE
WATER WILL BOIL VIOLENTLY IN CONTACT WITH HOT OIL
Boiling water can splatter hot oil and may cause serious injury
FILTERING OIL