Filter
Top Products
– 26 –
CLEANING
WARNING: DISCONNECT THE ELECTRICAL POWER TO THE MACHINE AND FOLLOW
LOCKOUT/TAGOUT PROCEDURES BEFORE CLEANING.
COOKING COMPARTMENT DRAINS
Keep compartment drains running freely. Inspect compartment drains daily for blockage. Remove any
particles or debris from the perforated strainer daily (or more often if needed).
After cooking greasy foods or seafood, close the doors and operate each compartment for 15 to 30
minutes to flush any residual grease and oils down the compartment drain. Make a solution of warm
water and detergent and pour
1
/2 gallon (1.9 liters) of it down each compartment drain. Rinse by pouring
1
/2 gallon (1.9 liters) of hot water down each compartment drain.
BOILER BLOWDOWN
To prevent malfunction of controls and clogging, it is essential to blow down the boiler every day. This
will flush out any accumulated minerals from the feed water. It will also aid in preventing internal scale
buildup which would interfere with proper boiler operation. Failure to blow down the boiler every day
may void the steamer warranty. The presence of minerals in suspension is indicated by a murky or
milky condition in the first portion of the water drained.
WARNING:
THE WATER BEING DRAINED IS HOT AND UNDER PRESSURE. USE CARE WHEN
CLEANING
OR SERVICING THE BOILER.
After the steamer boiler has been in operation, press [ O ] and the boiler will blow down for
approximately 5 minutes, removing sediment, scale or lime buildup in the boiler.
COMPARTMENTS
Wash the inside of the compartment with a solution of warm water and detergent. Rinse with warm
water.
Once a week, thoroughly clean the exposed surfaces (sides, front, door and top) with a damp cloth and
polish with a clean cloth. To remove discolorations, use a nonabrasive cleaner.
DOOR GASKETS
Clean the gasket sealing surface of the compartment doors to remove harmful food acids for maximum
gasket life. Do not use any solvents. Wash with a cloth moistened in a solution of mild detergent and
warm water. Rinse with a fresh cloth moistened with warm water to remove all traces of detergent.
Wipe dry with a clean cloth. Never apply food oils or petroleum lubricants directly to the door gasket.
Petroleum-based solvents and lubricants will reduce gasket life.
LEAVE COMPARTMENT DOORS OPEN
CAUTION: Leave the compartment doors slightly open when the steamer is not in use. When
the compartment is idle, never latch the door and apply pressure to the door gasket. Leaving
the gasket under pressure can cause permanent deformation and reduce gasket life.