Filter
Top Products
AJ-64 Conveyor Series Technical Manual 7610-003-30-93
Issued: 05-02-2006 Revised: N/A
SECTION 5: PARTS SECTION
57
AJ-86 & AJ-100 CONTROL BOX ASSEMBLY (CONTINUED)
ITEM QTY DESCRIPTION Mfg. No.
1 1 Electrical Box Weldment 05700-041-88-50
2 1 Decal, L1-L2-L3 09905-101-12-66
3 1 Terminal Block 05940-011-48-27
4 6 Lockwasher, #10 05311-273-02-00
5 2 Screw, 10-32 x 3/4” Long Phillips Trusshead 05305-011-62-17
6a 1 Light, Amber (Wash Heater Overload) (Not used on steam or gas models) 05945-111-44-44
6b 1 Light, Amber (Rinse Heater Overload) (Not used on steam or gas models) 05945-111-44-44
7 1 Wire Lug, 2 AWG to 14 AWG 05940-200-76-00
8 1 Light, Red (Power) 05945-111-44-45
9 1 Din Rail 05700-021-94-96
10 3 Screw, 10-32 x 1/2” Long Phillips Trusshead 05305-011-39-36
11 1 Washer, Flat, 1/4” 05311-174-01-00
12 1 Decal, Ground 09905-011-86-86
13 1 Terminal Board 05940-002-78-97
14a 1 Drive Motor Contactor 05945-111-68-38
14b 1 Wash Pump Motor Contactor 05945-111-68-38
14c 1 Recirculating Rinse Pump Motor Contactor 05945-111-68-38
14d 1 Prewash Pump Motor Contactor 05945-111-68-38
15 1 Circuit Breaker (208 & 230 volt models only) 05925-011-68-34
16a 1 Recirculating Rinse Pump Motor Overload (See motor overloads chart) N/A
16b 1 Wash Pump Motor Overload (See motor overloads chart) N/A
17 1 Switch, ON/FILL & OFF/DRAIN 05930-011-49-55
18 1 Drive Motor Overload (See motor overloads chart) N/A
19 1 Terminal Board 05940-021-89-41
20 2 Heater Contactor (Not available on seam models) 05945-002-24-70
21 2 Screw, 10-32 x 3/8” Long Phillips Trusshead 05305-173-12-00
22 1 Transformer 05950-011-68-35
23 4 Locknut, 10-24 with Nylon Insert 05310-373-01-00
24 1 Fuse Holder (460 volt models only) 05920-011-72-89
25 1 Fuse (460 volt models only) 05920-011-72-88
26 12 Screw, 6-32 x 3/8” Long Phillipshead 05305-171-02-00
27 7 Control Relay, 2 Pole (5 for Gas models, 1 not shown) 05945-111-35-19
28 3 Relay, 3 Pole (Gas models only) 05945-111-72-51
29a 1 Rinse Thermometer, 96” (L-R & R-L models) 06685-111-68-49
Decal, Rinse 180°F 09905-002-97-62
29b 1 Power Rinse Thermometer, 96” (L-R models) 06685-111-68-49
29b 1 Power Rinse Thermometer, 120” (R-L models) 06685-111-87-13
Decal, Power Rinse 160°F 09905-003-01-31
30a 1 Wash Thermometer, 120” (L-R models) 06685-111-87-13
30a 1 Wash Thermometer, 96” (R-L models) 06685-111-68-49
Decal, Wash 150°F 09905-002-97-61
30b 1 Prewash Thermometer, 120” (L-R & R-L models) 06685-111-87-13
31 1 Power Rinse Thermometer 06685-111-87-13
Decal, Power Rinse 160°F 09905-003-01-31
32 1 Decal, Gauge 09905-021-82-65
Items not shown:
Grommet, 1/2” OD x 3/8” ID 05325-011-46-73
Bushing, Heyco SB100 05975-210-09-00
Plug, Heyco 2700 G-875 05975-011-47-81
Control Box Cover 05700-031-66-88
Control Box Cover Hinge Weldment 05700-021-68-57
Control Hinge Rod 05700-011-68-58
MANUAL/DELIME Switch (Located on rear of contol box) 05930-301-22-18
MANUAL/DELIME Decal 09905-011-74-61
Copper Conductors Only Decal 09905-011-47-35
Control Box Leg 05700-011-71-47