Filter
Top Products
TABLE OF CONTENTS
The serial tag is a permanently affixed sticker on
which is recorded vital electrical and refrigeration data
about your Traulsen product, as well as the model
and serial number. This tag is located in the right
interior compartment on all full size undercounter and
equipment stand models.
I. THE SERIAL TAG
-1-
FORT WORTH, TX.
SERIAL MODEL
VOLTS Hz PH
TOTAL CURRENT AMPS
MINIMUM CIRCUIT AMPS
MAXIMUM OVERCURRENT PROTECTION AMPS
LIGHTS WATTS
HEATERS AMPS
REFRIGERANT TYPE OZ
DESIGN PRESSURE HIGH LOW
REFRIGERANT TYPE OZ
DESIGN PRESSURE HIGH LOW
370-60294-00 REV (A)
READING THE SERIAL TAG
• Serial = The permanent ID# of your Traulsen
• Model = The model # of your Traulsen
• Volts = Voltage
• Hz = Cycle
• PH = Phase
• Total Current = Maximum amp draw
• Minimum Circuit = Minimum circuit ampacity
• Lights = Light wattage
• Heaters = Heater amperage (Hot Food units only)
• Refrigerant = Refrigerant type used
• Design Pressure = High & low side operating
pressures and refrigerant charge
• Agency Labels = Designates agency listings
VII. INTELA-TRAUL
a-Control Features Page 7
b-Alarm Explanations Page 8
c-Control Panel Page 9
d-Parts Assembly Page 9
e-Notes To The User Page 10
f-Enter The Customer Access Code Page 10
g-Customer Service Parameters Page 11
h-Adjusting Thermostat Set Point High Page 11
i-Adjusting Thermostat Set Point Low Page 12
j-Changing The Temperature Scale Page 12
k-Setting The 24-Hour Clock Page 13
l-Setting The Date Page 14
m-Setting Daylight Savings Time Page 14
n-Starting A Manual Defrost Page 15
o-Setting Defrost Lockouts Page 16
p-Adjusting The Dewpoint Compensation Factor Page 17
q-Setting The Audible Alarm Style Page 17
r-Viewing Sensor Temperatures Page 18
VIII. TROUBLE SHOOTING GUIDE Page 19
IX. WARRANTY INFORMATION Page 20
X. OTHER
a-Service Information Page 21
b-Spare Parts Page 21
c-Warranty Registration Page 21
XI. PARTS LIST Page 21
XII. INDEX Page 22
I. THE SERIAL TAG Page 1
II. RECEIPT INSPECTION Page 2
III. INSTALLATION
a-Location Page 2
b-Packaging Page 2
c-Installing Legs Page 2
d-Installing Casters Page 3
e-Shelf Pins Page 3
f-Cord & Plug Page 3
g-Power Supply Page 3
h-Wiring Diagram Page 3
i-Placing Equipment On Top Of Cabinet Page 3
IV. OPERATION
a-Refrigerators Page 3
b-Freezers Page 3/4
c-Condensate Removal Page 4
V. CARE & MAINTENANCE
a-Cleaning The Condenser Page 4
b-Hinge Replacement Page 4
c-Replacing The Gaskets Page 4
d-Cleaning The Exterior Page 4
e-Cleaning The Interior Page 4
VI. MISC. OPERATIONS
a-Adjusting The Shelves Page 4/5
b-Re-Hinging The Door(s) Page 5
c-Removing The Drawers Page 5
d-Removing The Powerpack Page 5/6