Middleby Marshall P/N 60250 Oven User Manual


  Open as PDF
of 36
 
2P/N60250September28,2012
I. OVEN SPECIFICATIONS
Table 1-1 Dimensions Single Oven Double Oven Triple Ove
Overall Height 48-3/16″ (1219mm) 62-3/4″ (1575mm) 78-11/16″ (1981mm)
Overall Depth 60″ (1524mm) 60″ (1524mm) 60″ (1524mm)
Overall Length 76-1/2″ (1930mm) 76-1/2″ (1930mm) 76-1/2″ (1930mm)
Conveyor Width – belt width is 32″ 33-1/2″ (838mm) 33-1/2″ (838mm) 33-1/2″ (838mm)
or 2 × 15″ (381mm) or 2 × 15″ (381mm) or 2 × 15″ (381mm)
Shortened Exit Conveyor - 24″ Single Oven Double Oven Triple Ove
Overall Depth 52.75″ (1340mm) 52.75″ (1340mm) 52.75″ (1340mm)
Overall Length 69″ (1753mm) 69″ (1753mm) 69″ (1753mm)
* All other dimension are the same
Recommended Minimum Clearances
Rear of Oven to Wall 3″ (76mm) 3″ (76mm) 3″ (76mm)
Control end of conveyor to Wall 1″ (25.4mm) 1″ (25.4mm) 1″ (25.4mm)
Non-control end of conveyor to Wall) 1″ (25.4mm) 1″ (25.4mm) 1″ (25.4mm)
Table 1-2: General Specications PS740 GAS 32″ Belt 24″ Belt
Weight 1150 lbs. (522kg) 1150 lbs. (522kg)
Rated Heat Input 99,000 BTU (25,000kcal, 29 kW/hr) 99,000 BTU (25,000kcal, 29 kW/hr)
Maximum Operation Temperature 600°F / 315°C 600°F / 315°C
Air Blowers Two Blowers at 1900 RPM Two Blowers at 1900 RPM
Warmup Time 15 min. 15 min.
Table 1-3: Electrical specications for PS740G gas ovens
Main Blower Control Circuit Phase Freq Current Poles Wires
Voltage Voltage Draw
208-240VAC 208-240VAC 1Ph 50/60Hz 11-9.6 Amp 2 Pole 3 Wire (2 hot, 1 gd)
Table 1-4: Gas orice and pressure specications for PS740G gas ovens
Gas Main Orice I.D. Supply (Inlet) Orice (Manifold) Bypass
Type PS740G Pressure Pressure Pressure
Natural 0.1065″ (0.120mm) 8-12″ W.C. (19.9 - 29.9mbar) 3.5″ W.C. (8.7mbar) 0.25-0.3″ W.C. (0.6-0.8 mbar)
Propane 0.067″ (1.9mm) 11-14″ W.C. (27.4 - 34.9mbar) 10.0″ W.C. (24.9mbar) 0.9-1.0″ W.C. (2.2-2.5 mbar)
IMPORTANT – Additional electrical information is provided on the oven’s serial plate, and on the wiring diagram inside the
machinery compartment.
NOTE
Wiring Diagrams are contained in Section 5 of this Manual
and are also located inside the oven at the
bottom of the Control Panel.
Additional electrical information is provided on the oven's serial plate.
This Manual Must Be Kept For Future Reference
GAS ORIFICE AND PRESSURE SPECIFICATIONS (PER OVEN CAVITY) - CE OVENS
Supply(Inlet)Pressure
IT,PT,ES,SE,
Main UK,CH,IT,AT, SE,CH,AT,DK, BE,IE,IT,PT, Orice Rated
Gas Orice DK,FI NL DE BE,FR FI,DE,NL ES,UK (Manifold) Heat
Type dia.
I
2H
I
2L
I
2E
I
2E+
I
3B/P
I
3+
Pressure Input
G20 0.120″ 20 -- 20 20 -- -- 11.21 22.36
(3.05mm) mbar mbar mbar mbar kW-hr.
G25 0.120″ -- 25 -- -- -- -- 16.19 22.36
(3.05mm) mbar mbar kW-hr.
G30 0.075″ -- -- -- -- 29or50 28-30,37 26.2 22.59
(1.9mm) mbar or50mbar mbar kW-hr.
 previous next