Alto-Shaam CombiOven Oven User Manual


  Open as PDF
of 58
 
ExprEssTouch opErATING INsTrucTIoNs
CT EXPRESS STEP BY STEP OPERATION MANUAL • 21
CombiSmoker® ProCedureS
LOAD WOOD CHIPS
• Measureonecontainerfullofdrywoodchips.
• Soakdrychipsinwaterfor5minutes.
• Shakeexcesswateroffwoodchips.
• Placemoistenedchipsbackintothecontainer
andpositionthecontainersecurelyonthetwoprongs
locatedontheinteriorsidepaneloftheoven.
Afullcontainerofwoodchipswillproducesmokeforan
approximateperiodofonetotwohoursdependingonthe
cookingtemperaturebeingusedfortheselectedproduct.
TherecommendedTouchrecipeshavebeentestedtoensure
completeproductsmokepenetrationandfullsmokeavor.
CHEF OPERATING TIP
Productssuchasribsthatrequireheaviersmokepenetration
toreachfullsmokeavorshouldremainintheovenafter
cookinghasbeencompleted.Donotopentheovendoor.
SettheovenintheLowTemperatureSteamModeat140°to
160°F(60°to71°C)andallowtheproducttoremaininthe
ovenforaperiodofonehour.
If you would like assistance, you are invited
to contact an Alto-Shaam corporate chef for
recommendations.
NOTE: Always keep the oven door closed whenever
operating the smoking function.
TheTouchCombiSmokercanbeoperatedwithoutusing
thesmokingfunction.Afterusingtheovenasasmoker,
however,itisnecessarytocleantheoveninordertoprevent
atransferofsmokeavortonon-smokedproducts.Cleaning
instructionsareprovidedinthismanual.
5015597
AVAILABLE FROM ALTO-SHAAM
WOOD CHIPS 20 pound bulk packs
Apple WC-22543
Hickory WC-2829
Cherry WC-22541
Sugar Maple WC-22545
THE TOTAL WEIGHT OF
WOOD CHIP BULK PACKS
MAY VARY DUE TO HIGH
MOISTURE CONTENT
WHEN PACKAGED.
THE USE OF IMPROPER MATERIALS FOR
THE SMOKING FUNCTION COULD RESULT IN
DAMAGE, HAZARD, EQUIPMENT FAILURE,
OR COULD REDUCE THE OVERALL LIFE
OF THE OVEN.
DO NOT USE SAWDUST FOR SMOKING.
DO NOT USE WOOD CHIPS SMALLER
THAN THUMBNAIL SIZE.
CAUTION
DO NOT OPEN THE OVEN DOOR DURING THE
SMOKING FUNCTION. The introduction of outside
air in the oven compartment may cause the wood
chips to flame.
Whensmokingiscompleted,removesmokerboxfromoven.
Disposeofwoodchipsinareproofwastereceptacle.
 previous next