Filter
Top Products
19
620918702
TROUBLESHOOTING
IMPORTANT: Only qualified Personnel should service internal components or electrical wiring.
WARNING: If repairs are to be made to a syrup system, disconnect syrup supply from the
applicable syrup system, then relieve the system pressure before proceeding. If repairs are
to be made to the CO
2
system, stop dispensing, shut off the CO
2
supply, then relieve the
system pressure before proceeding. If repairs are to be made to the unit electrical system, make
sure electrical power is disconnected from the unit before proceeding.
Should your unit fail to operate properly, check that there is power to the unit and that the hopper con-
tains ice. If the unit does not dispense, check the following chart under the appropriate symptoms to
aid in locating the defect.
Trouble Probable Cause Remedy
BLOWN FUSE OR CIRCUIT
BREAKER
A. Short circuit in electrical wiring. A. Repair electrical wiring.
B. Inoperative 24 VAC
transformer.
B. Replace transformer.
C. Inoperative agitator motor. C. Replace agitator motor.
D. Shorted motor. D. Replace Agitator Auger motor.
AGITATOR DOES NOT TURN,
AUGER DOES NOT TURN.
A. No electrical power. A. Restore electrical power.
B. Bent depressor plate (does not
actuate switch).
B. Replace depressor plate.
C. Inoperative dispensing switch. C. Replace dispensing switch.
D. Inoperative interlocks, lids not
closed.
D. Replace interlocks.
E. Inoperative timer board. E. Replace timer board.
F. Inoperative 24 VAC
transformer.
F. Replace transformer.
ICE DISPENSES
CONTINUOUSLY.
A. Stuck or bent depressor plate
(does not release switch).
A. Replace depressor plate.
B. Inoperative dispensing switch. B. Replace dispensing switch.
C. Improper switch installation. C. Correct switch installation.
D. Inoperative timer board. D. Replace timer board.
SLUSHY ICE. WATER IN
HOPPER.
A. Blocked drain. A. Unplug and flush out the drain.
B. Unit not sitting level. B. Level the unit.
C. Poor ice quality due to water
quality or icemaker problems.
C. Install water filter system. For
icemaker problems, consult
icemaker manual.
D. Improper use of flaked ice. D. Use correct ice.
AGITATOR TURNS, AUGER
DOES NOT TURN.
A. Inoperative auger motor. A. Replace auger motor.
B. Inoperative or improper setting
of speed control.
B. Replace speed control or
re–adjust speed control.