Amana RS2320006 Oven User Manual


 
Disassembly Procedures
11 RS2320006 Rev. 0
To avoid risk of electrical shock, personal injury or death;
disconnect power supply source before servicing, unless
testing requires it.
WARNING
!
Oven Door Handle, Outer/Inner Glass, and
Door Hinges
1. Open or remove storage drawer to avoid damaging
finish.
2. Fully open the oven door, while open rotate both
hinge locking tabs into the LOCK position.
Hinge Lock
Oven
Door
3. Close oven door about all the way. The hinge locking
tabs will prevent the door closing completely.
4. Lift up equally on both sides of oven door. Hinges will
disengage from hinge receivers and oven door can
be removed.
5. Place oven door, with outer door glass facing
downward on a padded flat surface.
6. While supporting outer door glass, remove screws
securing left and right side the OVEN DOOR
HANDLE.
7. Again support outer door glass and turn door
assembly so outer door glass is facing upward and
remove outer oven door glass.
NOTE: May need to loosen screws in bottom glass
retainer.
8. Remove screws and neoprene washer from the
bottom of OVEN DOOR HINGE and one screw
securing oven door hinge to the door assembly.
NOTE: Hinges are interchangeable.
9. Remove screws securing top of door trim. Lift up and
twist trim towards bottom of door to disengage plastic
finger tabs.
10.All outer perimeter door trim can now be removed.
11.After removing the OFFSET screws from left and
right door glass trim, access is gained to the door
glass heat shield.
12.Remove screws from each side and screws from top
of door glass heat shield. Note position of plastic door
handle supports remove same.
13.Lift out galvanized insulation retainer and fiberglass
insulation.
14.Remove the tempered glass panes individually as
well as the glass frame.
NOTE: Tempered glass panes do not have an inner or
outer side. Be careful of fingerprints before
reassembly.
NOTE: Position replacement hinges into LOCK
position by using channel lock pliers PRIOR to
installing oven door on range.
Door
Handle
Oven
Door
Window
Door Glass
Heat Shield
Top Door
Trim
Side Door
Trim
Side Door
Trim
Glass Support
Heat
Shield
Window
Glass
Window
Frame
Door
Hinge
Door
Hinge
Oven
Door
Backer
Door
Handle
Screw
Bushing