Filter
Top Products
IntelliCarb Training Manual
Publication Number: TP01071 - 38 - © 2004, IMI Cornelius Inc.
DISPENSER TROUBLESHOOTING
Should your unit fail to operate properly, check that there is power to the unit and that the hopper
contains ice. If the unit does not dispense, check the following chart under the appropriate symptoms to
aid in locating the defect.
Trouble Probable Cause Remedy
BLOWN FUSE OR CIRCUIT
BREAKER.
A. Short circuit in wiring
B. Inoperable gate solenoid.
C. Inoperable agitator motor.
A. Repair wiring.
B. Replace gate solenoid.
C. Replace agitator motor.
GATE DOES NOT OPEN.
AGITATOR DOES NOT
TURN.
A. No power.
B. Bent depressor plate (does not
actuate switch).
C. Inoperable dispensing switch.
A. Restore power.
B. Replace depressor plate.
C. Replace dispensing switch.
GATE DOES NOT OPEN OR
IS SLUGGISH. AGITATOR
TURNS.
A. Inoperable gate solenoid.
B. Excessive pressure against gate
slide.
C. Inoperable rectifier.
A. Replace gate solenoid.
B. Adjust gate slide.
C. Replace rectifier.
ICE DISPENSES CONTINU-
OUSLY.
A. Stuck or bent depressor plate
(does not release switch).
B. Inoperable dispensing switch.
C. Improper switch installation.
A. Replace depressor plate.
B. Replace dispensing switch.
C. Make sure switch is installed
properly.
SLUSHY ICE. WATER IN
HOPPER.
A. Blocked drain.
B. Unit not sitting level.
C. Poor ice quality due to water qual-
ity or icemaker problems.
D. Improper use of flaked ice.
A. Unplug drain.
B. Level the unit.
C. Correct water quality or repair ice-
maker.
D. Call Service Person.
BEVERAGES DO NOT DIS-
PENSE
A. No 24 volts power to faucets.
B. No CO
2 pressure.
A. Restore 24 volt power to faucets.
B. Restore CO 2 pressure.
BEVERAGES TOO SWEET A. Carbonator not operating. A. Repair carbonator.