Filter
Top Products
©2004 Maytag Services 16023522 C–15
Conversion Instructions (Models AGR4400AD*, AGR4412AD*,
MGR4451AD*, MGR4452AD*, PGR4420LD*, CGR1425AD*, CGR1415AD*,
CGR1110AD*, CP31600AD*)
Air Shutter
a. The approximate length of the flame of oven burner is
a 1/2 inch distinct inner blue flame, figure 7.
b. Oven burner flame can be checked as follows:
1. Yellow flame on burner - open burner air shutter to
the widest opening that will not cause the flame to lift
or blow off the burner when cold. (See #2 on figure
8.)
2. Distinct blue flame but lifting - close burner air
shutter to the point where it will not cause the flame
to lift or blow off the burner when cold. (See #2 on
figure 8.)
FIGURE 8
FIGURE 7
FIGURE 9
3
LOCK
SCREW
AIR SHUTTER
2
1
ORIFICE
HOOD
AIR SHUTTER
NATURAL POSITION
AIR SHUTTER
LP POSITION
Conventional Burners
FIGURE 10
3/4²FLAME
ORIFICE
HOOD
AIR
SHUTTER
c. The oven burner air shutter adjustment is the same on
ranges with a gas pilot or electric ignition.
d. Sealed burner adjustment. Adjust burner air shutter to
the widest opening that will not cause the flame to lift or
blow off the burner when cold according to figure 9.
NOTE: Correctly adjusted sealed burners, can have
flames that will lift or blow without a pot over the burner.
These should be adjusted with a pot in place.
e. Conventional burner adjustment. Open the air shutters
or the burners so that the square hole is completely
uncovered (see figure 10).