Filter
Top Products
GENERAL
Oven cleaners are corrosive and can cause chemical burns. Rubber gloves, goggles and protective
clothing are required. Read and follow the instructions for the oven cleaner.
Safety standards require that, when the rotary oven’s electric supply line is properly connected to the
electrical power supply, an adequate means must be provided to limit movement of the oven without applying stress
to the electrical conduit. This means that, as part of the installation, the oven must be secured to either the wall or
the floor to limit movement of the oven and, thus, preventing damage to the flexible electrical conduit during cleaning,
maintenance and service operations.
REFERENCE INFORMATION
TSB'S & TSI'S
NOTE: Links or references to the TSB's are provided
here and in the appropriate sections of service
manual.
TSB 1381 KA7E ROTARY OVEN SCRAMBLED VFD DISPLAY.
TSB 1383
ROTISSERIE OVENS HR5E, HR7E AND KA7E NEW DRIVE MOTOR
ASSEMBLIES.
See Multimedia
section in TIS.
TSB 1400 KA7E - LEAKS AT DRIVE ARM GASKET DURING WASH CYCLE.
TSB 1417 KA7E - CLOGGING AT INPUT AND OUTPUT OF PERISTALTIC PUMPS.
See Multimedia
section in TIS.
TSI
HR7E AND KA7E ROTISSERIE OVEN ROTOR CRANK ARM DISENGAGING
FROM ROTOR.
See Multimedia
section in TIS.
Instructions & Specifications
Model Specifications Instructions Manual
KA7E F-40182 F-35521
KA7EM F-40287 F-45111
INTRODUCTION
All pictures and illustrations shown are of a KA7E
unless otherwise specified. When specific model
number designations are needed for clarity, they are
added to the procedure or picture.
General
• Capacity of the KA series seven spit oven is 21
to 35 chickens.
• Stacking kit available to stack ovens.
• Refer to the Specifications sheet for oven
Installation details and Instructions manual for
operating and cleaning instructions.
KA7E - Model Description
• Rotisserie oven with automatic clean cycle.
• Electronic control with message center, time,
temperature and program display features.
• Pass through controls on the unload side to
snooze cook cycle, silence beeper and stop cook
cycle.
• Equipped with grease assist and chemical
cleaner peristaltic pumps.
• Pump for automatic draining.
KA7EM - Model Description
• Rotisserie oven without automatic clean cycle
features (manual cleaning).
• Electronic control with time, temperature and
program display features.
• Manual drain valve.
KA SERIES ELECTRIC ROTARY OVENS - GENERAL
F25294 Rev. A (0412) Page 4 of 72