Filter
Top Products
v
326142000
TABLE OF CONTENTS (cont’d)
Page
ALL FAULT MESSAGES NOT OPERATING. 62. . . . . . . . . . . . . . . . . . . . . . . . . .
‘‘CO2 OUT’’ FAULT MESSAGE GOES ON DURING OPERATION. 63. . . . . . .
‘‘H2O OUT’’ FAULT MESSAGE GOES ON DURING OPERATION. 63. . . . . . .
‘‘SYRUP 1’’ OR ‘‘SYRUP 2’’ FAULT MESSAGE GOES ON DURING
OPERATION. 63. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
‘‘ERROR 1’’ OR ‘‘ERROR2’’ FAULT MESSAGE GOES ON DURING
OPERATION. 63. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FREEZE CYLINDER AUTOMATIC DEFROST CYCLE DOES NOT
OPERATE. 63. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
UNIT DOES NOT GO OFF AUTOMATIC DEFROST CYCLE. 63. . . . . . . . . . .
MANUAL DEFROST CYCLE DOES NOT OPERATE WHEN ‘‘DEFROST’’
SWITCH IS PRESSED. 63. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING PRODUCT BLENDER TANKS AND CARBONATOR. 64. .
DEFROST CYCLE DOES NOT CANCEL AFTER PRESSING ‘‘CANCEL
DEFROST ’’ SWITCH. 64. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CARBONATOR WATER PUMP MOTOR WILL NOT OPERATE. 64. . . . . . . . .
CARBONATOR WATER PUMP WILL NOT SHUT OFF. 64. . . . . . . . . . . . . . . . .
ERRATIC CARBONATOR WATER PUMP CYCLING. 65. . . . . . . . . . . . . . . . . .
TROUBLESHOOTING DISPENSED PRODUCT. 65. . . . . . . . . . . . . . . . . . . . . . . . . . .
BRIX (WATER–TO–SYRUP) ‘‘RATIO’’ TOO LOW. 65. . . . . . . . . . . . . . . . . . . . .
BRIX (WATER–TO–SYRUP) ‘‘RATIO’’ TOO HIGH. 65. . . . . . . . . . . . . . . . . . . . .
IMPROPER PRODUCT DISPENSED. 65. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PRODUCT WILL NOT DISPENSE OUT OF DISPENSING VALVE, IN ONLY
SMALL AMOUNTS, OR ONLY LIQUID. 65. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FREEZE CYLINDER DOES NOT REFILL AT ALL TIMES WHEN
DISPENSING. 65. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FROZEN PRODUCT CONSISTENCY VARIES EXCESSIVELY. 66. . . . . . . . .
CYLINDER FREEZE–UP. 66. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ACCESSORIES AND TOOLS 66. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ACCESSORIES 66. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GENERIC FLAVOR TABS 66. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SERVICE TOOLS 66. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WARRANTY 78. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
LIST OF FIGURES
FIGURE 1. FCB (SOLID-STATE) POST-MIX TWO-FLAVOR DISPENSER 1. . . .
FIGURE 2. FLOW DIAGRAM 4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 3. FREEZE CYLINDER CUTAWAY VIEW 7. . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 4. BEATERS AND SCRAPER BLADES INSTALLATION 8. . . . . . . . . . . .
FIGURE 5. OPERATING CONTROLS 30. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 6. UNIT INTERNAL COMPONENTS 31. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 7. SELF-CLOSING DISPENSING VALVE 32. . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 8. SERVICING BEATER DRIVE SHAFT SEAL ASSEMBLY 32. . . . . . . . .
FIGURE 9. CONTROL PANEL 37. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 10. MASTER AND RELAY CIRCUIT BOARDS 39. . . . . . . . . . . . . . . . . . . . .
FIGURE 11. LIQUID CHECK VALVE ASSEMBLY 48. . . . . . . . . . . . . . . . . . . . . . . . . .